Title page for ETD etd-05132002-120642

Type of Document Dissertation
Author Brown, Michael Carey
URN etd-05132002-120642
Title Corrosion Protection Service Life of Epoxy Coated Reinforcing Steel in Virginia Bridge Decks
Degree PhD
Department Civil Engineering
Advisory Committee
Advisor Name Title
Weyers, Richard E. Committee Chair
Corcoran, Sean Gerald Committee Member
Cousins, Thomas E. Committee Member
Dillard, John G. Committee Member
Sagues, Alberto A. Committee Member
Sprinkel, Michael M. Committee Member
  • corrosion
  • epoxy coating
  • concrete
  • reinforcement
  • impedance
  • service life
Date of Defense 2002-05-03
Availability unrestricted
The corrosion protection service life extension provided by epoxy-coated reinforcement (ECR) was determined by comparing ECR and bare bar from 10 bridge decks built between 1981 and 1995. The objective was to determine the corrosion protection service life time extension provided by ECR field specimens with various degrees of coating adhesion: disbonded, partially disbonded, and wholly bonded coatings.

The size and length distributions of cracks in Virginia bridge decks were investigated to assess the frequency and severity of cracks. Correlation of cracks with chloride penetration was used to characterize the influence of cracking on deck deterioration. Cracks influence the rate of chloride penetration, but the frequency and width distributions of cracks indicate that cracks are not likely to shorten the overall service life of most bridge decks in Virginia.

Altogether, 141 drilled cores, 102 mm (4 inches) in diameter, were employed in this study. For each of the decks built with ECR, 10 to 12 cores were drilled through a top reinforcing bar adjacent to the previous study core locations. In addition, approximately 3 cores were drilled through a top reinforcing bar at a surface crack location. Laboratory testing involved nondestructive monitoring using advanced electrochemical techniques to periodically assess the corrosion state of the steel bars during cyclic exposure to chloride-rich solution over 22 months of treatment. Time of corrosion initiation and time of cracking (where applicable), as well as chloride content of the concrete before and after treatment, were used in the analysis.

Less than 25 percent of all Virginia bridge decks built under specifications in place since 1981 is projected to corrode sufficiently to require rehabilitation within 100 years, regardless of bar type. The corrosion service life extension attributable to ECR in bridge decks was found to be approximately 5 years beyond that of bare steel.

  Filename       Size       Approximate Download Time (Hours:Minutes:Seconds) 
 28.8 Modem   56K Modem   ISDN (64 Kb)   ISDN (128 Kb)   Higher-speed Access 
  MCBrownDissertation.pdf 2.30 Mb 00:10:38 00:05:28 00:04:47 00:02:23 00:00:12

Browse All Available ETDs by ( Author | Department )

dla home
etds imagebase journals news ereserve special collections
virgnia tech home contact dla university libraries

If you have questions or technical problems, please Contact DLA.